Embodiments of the present method and system permit an effective method for determining the optimum selection of pulse width modulation polarity and type including determining machine parameters, inputting the machine parameters into a predicted duty cycle module, determining the optimum polarity of the pulse width modulation for a predicted duty cycle based on a pulse width modulation generation algorithm, and determining the optimum type of the pulse width modulation for a predicted duty cycle based on the pulse width modulation generation algorithm.

A lower limit value setting unit (52) variably sets a lower limit value (Vth) of a target voltage (Vh*) in a range of a voltage that is higher than the maximum value of voltages (Vb1, Vb2) of power storage devices and is not affected by a dead time provided for converters, based on temperatures (Tb1, Tb2) and required electric powers (Pb1*, Pb2*). A maximum value selection unit (53) sets the maximum value among the voltages (Vb1, Vb2) of the power storage devices and required voltages (Vm1*, Vm2*) of motor-generators, as the target voltage. A target voltage limiting unit (54) compares the target voltage with the lower limit value (Vth), and if the target voltage is lower than the lower limit value (Vth), the target voltage limiting unit (54) sets the lower limit value (Vth) as the target voltage (Vh*).

A method for monitoring input power to an electronically commutated motor (ECM) is described. The method includes determining, with a processing device, an average input current to the motor, the average input current based on a voltage drop across a shunt resistor in series with the motor, measuring an average input voltage applied to the motor utilizing the processing device, multiplying the average input current by the average voltage to determine an approximate input power, and communicating the average input power to an external interface.

A device and method to determine the stopping rotor position of a washing machine motor includes an inverter, a permanent magnet synchronous motor, and an electronic motor controller. The controller determines the stopped rotor position of the motor by measuring induced currents in the stator field coils of the motor. While the motor is de-energized and slowly rotating, the controller directs the inverter to connect all of the stator field coils of the motor together. The stator field coils may be connected to a common D.C. rail, output from an A.C.-D.C. converter of the washing machine. In an embodiment, the controller determines the rotor position based on the polarities of current induced in the stator field coils. In another embodiment, the controller determines the rotor position based on the phase angle and angular frequency of the three phase currents, transformed into a stationary reference frame.

The invention relates to an electric motor assembly, particularly for driving a fan for an engine cooling system and/or an air conditioner of a motor vehicle, comprising an electric motor and a motor control device for activating the electric motor. According to the invention, the motor control device can be adjusted according to a characteristic curve (1,2,3,4) of the electric motor and/or of the fan, and thereby the power and/or rotational speed of the electric motor can be adjusted.

A system to monitor the temperature of power electronic devices in a motor drive includes a base plate defining a planar surface on which the electronic devices and/or circuit boards within the motor drive may be mounted. The power electronic devices are mounted to the base plate through the direct bond copper (DBC). A circuit board is mounted to the base plate which includes a temperature sensor mounted on the circuit board proximate to the power electronic devices. The temperature sensor generates a digital signal corresponding to the temperature measured by the sensor. A copper pad is included between each layer of the circuit board and between the first layer of the circuit board and the sensor. The circuit board also includes vias extending through each layer of the board. The copper pads and vias establish a thermally conductive path between the temperature sensor and the base plate.

The present application discloses a control circuit for a power tool and a method for manipulating the power tool. The control circuit has a detection circuit for battery packs, a calculating control circuit, a battery capacity indicating circuit for indicating the calculation result of the battery capacity, and a current measure and calculating circuit for measuring the current flowing through motors. The calculation result further includes the voltages consumed by the battery pack internally and the discharge loop. The method for manipulating the power tool includes pressing the switch to electrically connect the motor and the battery pack, measuring the parameters of the battery pack and allowing the motor to operate or not according the measured parameters. Further, after the motor is in operation, the battery capacity is calculated and the results are displayed.

A motor driving apparatus is applied to a fan and motor mechanism and a voltage supply unit. The motor driving apparatus includes a motor driving unit, a voltage division resistor, a first resistor, a first switch unit, a second resistor, a second switch unit, a third resistor, a third switch unit, a transistor switch, and a pulse width modulation unit. The first switch unit, the second switch unit, and the third switch unit are configured to select the rotational speed upper limitation of the fan and motor mechanism for suppressing noise.

An integrated circuit for controlling an electric motor, which has a primary component with a coil and a permanently magnetic secondary component cooperatively connected via an air gap to the primary component, has a semiconductor substrate in which are integrated a microcontroller and/or a pre-amplifier for controlling the coil of the electric motor. For detecting the position of the permanently magnetic secondary component, at least two magnetic field sensors with their measurement axes aligned crosswise relative to each other are integrated in the semiconductor substrate.

A control circuit for a fan includes a fan controller, a switch controller, and a frequency detector. When a pulse-width modulation (PWM) signal output pin of the fan controller outputs PWM signals, the frequency detector outputs a high level signal, connecting an input pin of the switch controller to an output pin of the switch controller. The fan receives the PWM signal. When the PWM signal output pin of the fan controller does not output PWM signals, the frequency detector outputs a low level signal, such that the output pin of the switch controller does not output any signal. In this state, the fan receives a high level signal through a resistor and a power supply, enabling the fan to continue operating.

The invention relates to a method for detecting blocking or sluggishness (M1, M3) of a DC motor (2). The method comprises the following steps: applying a voltage pulse (Uv,t=Os) to the DC motor (2); monitoring a motor current (IMotor) flowing through the DC motor (2); detecting a maximum value of the motor current (IMotor) following the application of the voltage pulse; checking whether a change in the motor current (IMotor) after reaching the maximum value exceeds a specific amount; signalling the blocking or the sluggishness (M1, M3) of the DC motor (2) if the change in the motor current (IMotor) after reaching the maximum value exceeds the specific amount.

A control system (128) for controlling a switched reluctance (SR) machine (110) having a rotor (116) and a stator (118) is provided. The control system (128) may include a converter circuit (122) operatively coupled to the stator (118) and including a plurality of switches (132) in selective communication with each phase of the stator (118) and a controller (130) in communication with each of the stator (118) and the converter circuit (122). The controller (130) may be configured to determine a position of the rotor (116) relative to the stator (118), and generate a modulated switching frequency (152) based on the rotor position.

A rotation speed control circuit is disclosed. The rotation speed control circuit includes a temperature-controlled voltage duty generator, a pulse-width signal duty generator, a multiplier and a rotation speed signal generator. The temperature-controlled voltage duty generator converts temperature-controlled voltage to digital temperature-controlled voltage and executes linear interpolation operation according to a first setting data so as to output temperature-controlled voltage duty signal. The pulse-width signal duty generator coverts pulse-width input signal to a digital pulse-width input signal and executes linear interpolation operation according to a second setting data so as to output a pulse-width duty signal. The temperature-controlled voltage duty signal and the pulse-width duty signal are executed for multiplication by the multiplier so as to output mixing-duty signal. The rotation speed generator receives the mixing-duty signal and a third setting data, and executes a minimum output duty operation so as to output a pulse-width output signal.

The present invention discloses a controller and a method for improving motor driving efficiency. According to the present invention, multiple control parameters are inputted to the controller so that the controller can adjust timings of PWM driving signals for driving the motor to advance or delay the turned-ON or turned-OFF points, whereby the motor is driven efficiently.

The electric tool is powered by a secondary battery as a power source, and includes: an output section configured to be transmitted thereto a rotation of a motor directly or through a decelerator; a voltage measurement section that measures a battery voltage; a storage means that stores, as a reference voltage, a voltage value of the battery voltage measured preliminarily when a motor-lock is occurring; and a control means that controls a driving of the motor. The control means is configured to decide that the motor is being locked and then stop or decelerate the motor upon detecting that the battery voltage measured through the voltage measurement section is maintained lower than or equal to the reference voltage stored in the storage means for a predetermined period of time during the driving of the motor.

A method for controlling a motor is provided. The method comprises obtaining electrical signals of the motor with a signal unit, the electrical signals comprising a motor torque and an angular velocity, calculating a voltage phase angle of a voltage vector with a calculating component, wherein a command torque, the motor torque, the angular velocity and a voltage amplitude of the voltage vector are inputs of the calculating component, and wherein the voltage phase angle is a variable and the voltage amplitude is a constant. The method further comprises modulating the voltage phase angle and the voltage amplitude to a switching signal for controlling an inverter; converting a direct current voltage to the voltage vector according to the switching signal, and applying the voltage vector to the motor.

A motor driven power steering (MDPS) may include: a vehicle speed sensor configured to sense vehicle speed; a temperature sensor configured to sense a temperature of a power pack; a current sensor configured to sense an amount of current applied to the MDPS; a storage unit configured to store a thermal resistance value based on the vehicle speed with respect to the temperature of the power pack; and a control unit configured to calculate an estimated temperature by reflecting the thermal resistance value based on the vehicle speed with respect to the temperature of the power pack and the current amount applied to the MDPS into a temperature estimation function, and drive a motor according to the calculated estimated temperature.

Provided is an apparatus for compensating offset of a current sensor detecting a motor current supplied by an inverter for PWM (Pulse Width Modulation) control of a motor, the apparatus including a current controller providing a PWM signal generated based on the motor current detected by the current sensor to the inverter, calculating an offset using the motor current detected by the current sensor in response to presence and absence of the PWM control of the motor, or offset-compensating the motor current detected by the current sensor.

A system for determining motor speed of a brush DC motor in an apparatus, including a first filter for receiving a substantially DC component of the motor current and parameters corresponding to the brush DC motor, for calculating a speed estimate thereof; an adaptive bandpass filter having a center frequency corresponding to the speed estimate of the first filter, for receiving the motor current and substantially isolating a periodic current fluctuation thereof; a block for determining a frequency of the periodic current fluctuation, the current fluctuation corresponding to motor speed of the brush DC motor. The adaptive bandpass filter uses debounce filtering to reduce rapid filter passband switching, and a run-in period prior to passband switching to obviate transient effects of filter switching.

A circuit configuration for driving an electric motor includes a signal evaluation module, which stores a number of output patterns. An input pattern is specified, and as a function of the input pattern, one of the output patterns is output, by which the electric motor is driven.

A non-contact support platform system is provided for supporting a substantially flat object. The system includes a platform with a first plurality of pressure ports and a first plurality of vacuum ports for inducing a fluid cushion to support the object at a distance from the platform. The system further includes a second plurality of pressure ports located at a predetermined zone of the platform for increasing the distance of the object from the platform at the predetermined zone.

An improved rearward-hinged and forward-hinged, rotatable and tiltable receiving table for a agricultural bale transport vehicle that selectively tilts and rotates a layer of bales resting thereupon 90 degrees relative to a preceding bale layer on the transport vehicle to criss-cross tie a load of bales (a plurality of layers of bales) together in a load stack offloaded from the transport vehicle to the field for later pickup and movement or deposit in a bale storage area. Preferably, the bale transport vehicle is a mid-size or big bale stack wagon having a Mil-Stak® bale loader previously installed or concurrently being installed. The invention enables the lifting, tilting, rotating, and depositing of one mid-size or big bale or a plurality of mid-size or big bales from a rearward-hinged and forward-hinged bale receiving table of the bale transport vehicle onto a rear-hinged stack load table for consolation into a load with other layers of bales for transport from the field. The invention allows selective 90 degree rotation of a layer of bales relative to a preceding layer of bales of the bale stack on the rear-hinged stack load table.

A substrate processing system and substrate transferring method capable of transferring a substrate bi-directionally through the use of substrate transferring device provided between two rows of processing chambers arranged linearly, thereby improving the substrate-transferring efficiency, the substrate processing system includes a transfer chamber having at least one bi-directional substrate transferring device for bi-directionally transferring a substrate; and a plurality of processing chambers for applying a semiconductor-manufacturing process to the substrate, wherein the plurality of processing chambers are linearly arranged along two rows confronting each other, and the transfer chamber is interposed between the two rows of the processing chambers, wherein the bi-directional substrate transferring device have a moving unit inside the transfer chamber, and horizontally moved by a linear motor; and a bi-directional substrate transferring unit in the moving unit, the bi-directional substrate transferring unit transferring the substrate to the processing chamber through a bi-directional sliding movement.

Methods and apparatus for transferring one or more substrates from a first pressure environment to a second pressure environment is provided. In one embodiment, a load lock chamber is provided. The load lock chamber comprises a first circular housing, and a second circular housing disposed within and movable relative to the first circular housing, one of the first circular housing or the second circular housing comprising a plurality of discrete regions, wherein at least a portion of the plurality of discrete regions are in selective fluid communication with one of at least two vacuum pumps based on the angular position of the second circular housing relative to the first circular housing.

A panel-storing shelf comprises at least two support members, at least two tracks disposed around a surface of each of the at least two support members, respectively, to rotate about respective support member, and at least two brackets disposed on each of the at least two tracks, respectively, and at the same level, to hold the panel and rotate along with the track.

A safety feature prevents a two wheeled electric paper lift from raising a paper tray on uneven ground that includes a tilt switch positioned in parallel with an upper limit switch that controls the height in a vertical direction of the paper tray. When a tilt angle of the paper lift is greater than 5° the tilt switch will prevent the paper tray from being raised and thereby prevent the load on the paper tray from shifting or tipping over and causing injury to an operator.

A traction force control section of a wheel loader, when the determination conditions are satisfied during traction force control, increases the maximum traction force. The determination conditions include that the wheel loader is performing an excavation operation, that the vehicle speed is less than or equal to a prescribed speed threshold value, that the amount of operation of the accelerator operating member is equal to or more than a prescribed accelerator threshold value, and that the amount of operation of the inching operating member is less than or equal to a prescribed inching operation threshold value.

Reduction in cooling rate of a substrate having a lower temperature is suppressed because the substrate having a lower temperature is not affected by radiant heat of a substrate having a higher temperature while cooling a plurality of substrates in a cooling chamber. The substrate processing apparatus includes a load lock chamber configured to accommodate stacked substrates; a first transfer mechanism having a first transfer arm provided with a first end effector, and configured to transfer the substrates into/from the load lock chamber at a first side of the load lock chamber; a second transfer mechanism having a second transfer arm provided with a second end effector, and configured to transfer the substrates into/from the load lock chamber at a second side of the load lock chamber; a barrier installed between the substrates to be spaced apart from the substrates supported by a substrate support provided in the load lock chamber; and an auxiliary barrier unit installed between the substrate support and the barrier, wherein the auxiliary barrier unit is installed at places other than standby spaces of the end effectors.

A lift apparatus includes an elongated spine having a top portion and a bottom portion, a traveler operatively connected along the elongated spine for traveling up and down the elongated spine, a single linear actuator operatively connected to the traveler configured to move the traveler up and down the spine, an arm, and a single hinge operatively connected between the traveler and the arm allowing the arm to hinge outwardly and upwardly to a dump position when the traveler is proximate the top portion of the elongated spine.

An adapter for front forks of a front loading commodity collection truck allows the truck to collect from rear load and side load style containers. An intermediate container is carried on the forks of the truck. An engagement apparatus is mounted on the intermediate container and is laterally extendible to engage the commercial container at curbside and draw the container to the intermediate container. The engagement apparatus will lift the commercial container and tip it over the intermediate container. Controls in the cab of the truck control operation of the adapter. The adapter can be removed easily from the forks when a front loading refuse container is encountered.

An apparatus for loading and unloading a truck with cargo includes a mounting frame for attaching adjacent to a truck doorway. The mounting frame includes a first guide member forming a first channel, a first support member slideably received within the first channel, a second guide member forming a second channel, and a second support member slideably received within the second channel. A platform for supporting the cargo is pivotally coupled to the first support member and to the second support member. A power driven lift elevator slides the first support member within the first channel and slides the second support member within the second channel to thereby raise and lower the platform. A power driven platform elevator pivots the platform respect to the first and second support members to move the platform between horizontal and vertical positions.

A robot includes an arm having a base end portion rotatably installed through a joint part and a tip end portion in which an output shaft is installed; and a drive mechanism arranged within the arm and configured to drive the output shaft at a reduced speed. The drive mechanism includes a motor having a motor shaft, a driving pulley attached to the motor shaft, a driven pulley attached to the output shaft, at least one intermediate pulley provided between the driving pulley and the driven pulley, and a plurality of belts for operatively interconnecting the driving pulley and the driven pulley through the intermediate pulley.

The present teachings provide a method of controlling a remote vehicle having an end effector and an image sensing device. The method includes obtaining an image of an object with the image sensing device, determining a ray from a focal point of the image to the object based on the obtained image, positioning the end effector of the remote vehicle to align with the determined ray, and moving the end effector along the determined ray to approach the object.

While a second component is brought into contact with a first component, the first component and the second component are rotated with respect to each other around a specific rotation axis, and rotation of the first component and the second component is stopped when a moment created around the rotation axis exceeds a predetermined threshold.

Method for laterally replacing a heavy component of a plant assembly, the method including disconnecting the heavy component from other components of the plant assembly and from a base plate to which the heavy component is fixed; lifting the heavy component above the base plate with a lifting system provided within the base plate; connecting at least a pair of rails to the base plate, under the lifted heavy component, such that the at least a pair of rails extends at substantially a right angle relative to a longitudinal axis of the heavy component; lowering the heavy component on crawling mechanisms disposed on the at least a pair of rails; and laterally replacing the heavy component from the base plate and the other components of the plant assembly by actuating the crawling mechanisms.

A banknote stacking and sorting module comprises a banknote clamping and conveying sub-module, which comprises a clamping mechanism and a vertical reciprocating mechanism thereof. Clamping mechanism comprises bearing plate, support, cam, clamping rod and clamping spring. Cam is rotatably mounted on support. Clamping rod comprises clamping end, transmission end and hinged part between clamping end and transmission end. Hinged part of clamping rod is hinged on support. Cam engages with transmission end of clamping rod and can drive clamping rod in rotation around second rotary shaft between released position and clamped position. One end of clamping spring is fixed on support and the other end is connected to clamping end of clamping rod so as to provide to clamping rod an elastic force for clamping banknotes.

A carrier system for transporting an electric scooter behind a vehicle with a hitch receiver having a base platform, an extension ramp removably attached to a side edge of the base platform at an angle with respect to the base platform via a first attachment means, a base support tube where the base platform is mounted atop of, a hitch tube adapted to be telescopically received in a hitch receiver of a vehicle, wherein when the hitch tube is engaged with the base support tube and the tubes are secured together via a pivot bolt, the base support tube can pivot between a storage position and an extended position.

Boom drive apparatus for substrate transport systems and methods are described. The boom drive apparatus is adapted to drive one or more multi-arm robots rotationally mounted to the boom to efficiently put or pick substrates. The boom drive apparatus has a boom including a hub, a web, a first pilot above the web, and a second pilot below the web, a first driving member rotationally mounted to the first pilot, a second driving member rotationally mounted to the second pilot, a first driven member rotationally mounted to the boom above the a web, a second driven member rotationally mounted to the boom below the a web, and a first and second transmission members coupling the driving members to driven members located outboard on the boom. Numerous other aspects are provided.

The present invention is a cardboard sheet batch division device for dividing batches, disposed on the downstream side of a batch-forming device for separating loaded cardboard sheets and forming batches of a predetermined sheet count. The cardboard sheet batch division device for dividing batches comprises: a transfer conveyor for transferring batches formed by the batch-forming device in a predetermined transfer direction; and batch division means furnished with two separating members respectively contacting the leading edge portion and the trailing edge portion of a batch on the transfer conveyor, for dividing the batch into two sub-batches, upper and lower, by moving the two separating members relative to one another in a direction parallel to the predetermined transfer direction.

A synergy-based human-machine interface that uses low-dimensional command signals to control a high dimensional virtual, robotic or paralyzed human hand is provided. Temporal postural synergies are extracted from angular velocities of finger joints of five healthy subjects when they perform hand movements that are similar to activities of daily living. Extracted Synergies are used in real-time brain control, where a virtual, robotic or paralyzed human hand is controlled to manipulate virtual or real world objects.

A grain cart and foldable auger assembly having an upper auger assembly portion with a discharge portion, a lower auger assembly portion with an intake portion, and a compound angle joint that allows the upper auger assembly portion to be moved between operating and transport positions. When in an operating position, the upper auger portion and the lower auger portion are offset from each other by an operating offset angle. When in a transport position, the upper auger assembly portion is offset from the lower auger assembly portion by a transport offset angle such that the upper auger assembly portions folded across the front of the grain cart in a non-obstructive and non-protruding manner.

A wheelchair lift mounted on the rear of an automobile for transporting a wheelchair, scooter or other mobility device includes two or more sets of sensors. A first set of sensors is located at the distal ends of the wheelchair lift platform for use when the platform is horizontal. A 2nd set of sensors is located on the base of the wheelchair lift for use when the platform is folded vertically. The sensors alert a driver to the presence of objects in close proximity to the rear of the vehicle when driven in reverse. They switch automatically activates the base sensors when the platform is folded and the platform sensors when the platform is horizontal.

A crucible handling shuttle includes a pair of opposed dual crucible-gripping arms mounted on a rotatable head and moves between an induction furnace pedestal and a crucible loading station, such that one pair of arms pick up a crucible loaded with a preweighed sample, the shuttle moves to the induction furnace, where the other pair of arms grip and remove a spent crucible. The shutter head then rotates to deposit the new sample-holding crucible onto the pedestal and subsequently moves out of the furnace area to a sample disposal chute positioned between the crucible loading station and the furnace, whereupon the spent crucible is dropped for disposal. The shuttle head is then rotated and moved to the loading station to pick up a new crucible.

A front loader is provided with an indicator device. The indicator device is configured to indicate that the work implement is in an identical posture irrespective of a height position of the work implement, by aligning a rear end of the indicator rod with a rear end of the guide tube.

A connector device enables universal compatibility and interchangeability between any work tool accessory having a boom feature and any skid steer loader as well as controlled support of the work tool accessory. The connector device also prevents machine instability issues.

An apparatus for transferring articles is disclosed herein. The apparatus includes a layer formation table. The apparatus also includes means for supplying articles to the layer formation table. At least one row of the articles is formed at a first end of the layer formation table. The apparatus also includes a programmable robot including an end of arm tool for transferring the at least one row of the articles towards a second end of the layer formation table. The programmable robot is configured to form a plurality of rows of articles on the layer formation table. Each of the rows comprises a plurality of articles in side by side contact creating a void between adjacent articles in each of the rows. The programmable robot is configured to nest the articles of one of the rows in the voids of an adjacent row. The end of arm tool includes a multiplicity of guides which form lanes. The rows of articles fill the lanes. The end of arm tool includes clamping tools which lock the individual rows of articles between the guides.

A substrate transportation path is determined by first determining a trajectory of a first straight line passing through a start point, calculating a trajectory of a circular arc in contact with the first straight line, calculating a trajectory of a second straight line in contact with the circular arc and passing through the end point, then, if the position of the end point is changed, re-calculating the second straight line as a straight line passing through the changed end point and in contact with the circular arc, and allowing the center of the substrate holding unit to move on the first straight line, and then, move on the circular arc from a first contact point, followed by moving on the second straight line from a second contact point so as to reach the end point.

A robot system includes a crane unit, a crane moving mechanism, a robot, and a controller. The crane unit is to suspend a workpiece. The crane unit moves in a horizontal direction via the crane moving mechanism. The robot is to move the crane unit in the horizontal direction via the crane moving mechanism. The controller is configured to control the crane unit to move upwardly to suspend the workpiece after controlling the robot to bring the crane unit into an engaging state in which the crane unit engages with the workpiece located at a first position. The controller is configured to control the crane unit suspending the workpiece to move downwardly to place the workpiece at a second position after controlling the robot to move the crane unit toward the second position while the crane unit suspends the workpiece.

A manipulator and a method of generating the shortest path along which the manipulator moves to grip an object without collision with the object models a target object and a gripper into a spherical shape, measures a current position of the gripper and a position of the target object and a target position of the gripper, calculates an arc-shaped path in a two-dimensional plane along which the gripper needs to move by calculating an included angle of a triangle consisting of the position of the object and the current position and target position of the gripper, transforms the arc-shaped path in the two-dimensional plane into an arc-shaped path in a three-dimensional space using a transform matrix consisting of the position of the object and the current position and target position of the gripper, thereby automatically generating the shortest path of the manipulator.

An improved traffic sign is discussed. The traffic sign includes road reflectors, which reflect available light towards a driver indicating road lane divisions. A sensor module coupled with a vehicle can convert the reflected light to a binary word. The sensor module can further convert the binary word into traffic information, wherein a vehicle-mounted display displays information selected from received traffic information based on priority, time of receipt, and relevance. The improved traffic sign can also include an RFID tag configured to transmit traffic information to a vehicle-mounted receiver.